济南力诺瑞特太阳能销售服务中心
地址:济南市天桥区粟山路76号(药山派出所对面)
电话:0531-85715890
手机:15665707182
网站:http://www.sdlntyn.com
联系人:江经理
当前位置:首页 - 产品知识产品知识
夏季太阳能施工及保养注意事项
来源:http://www.sdlntyn.com 发布时间:2018-8-23 15:22:19 浏览次数:353
随着夏季气温的升高,天丰提醒大家做好夏季太阳能热水器的维护保养,防止出现真空管炸裂或者水箱抽瘪现象。
With the rise of summer temperature, Tianfeng reminds everyone to do a good job in summer solar water heater maintenance, to prevent the occurrence of vacuum tube bursting or water tank deflation phenomenon.
具体施工及保养中注意事项如下:
Details of construction and maintenance are as follows:
1.安装前认真检查水箱桶内是否干净,如有多余聚氨酯碎块贴在桶内壁或孔口(真空管插口处,箱桶侧面排气孔,溢流孔)内硅胶圈周围,用螺丝刀或长一点硬材质的竹片将其剔除,然后两人晃动水箱将碎屑晃出。
1. Before installation, carefully check whether the tank is clean or not, such as excess polyurethane fragments sticking to the inner wall of the bucket or hole (vacuum tube socket, side vent hole, overflow hole) around the silicone rubber ring, with a screwdriver or longer hard material bamboo chip to remove it, and then the two people shake the tank will shake the debris out.

2.安装中注意细节:首先组装太阳能支架,再装水箱,连接输水管道,然后打开上水阀门上水,水从插口处溢出后再装真空集热管(此时装真空管避免空晒,即使室外温度再高也不会炸管)。

济南力诺瑞特太阳能

2. Attention to the details of installation: first assemble the solar energy support, then fill the water tank, connect the water pipeline, then open the water supply valve, water overflow from the socket and then install the vacuum collector tube (at this time installed vacuum tube to avoid drying, even if the outdoor temperature is higher than the tube will not burst).
3. 水上满之后,再将真空集热管拔出1~2根,水从孔中泻出,一般可将水箱内残屑聚氨酯碎末冲出。
3. After the water is full, the vacuum collector pipe is pulled out 1-2, and the water is poured out of the hole. Generally, the residual polyurethane particles in the water tank can be washed out.
水泻完后从溢流孔(溢流管此时不装)目测桶内是否干净,如还有异物,重复动作,直到彻底干净为止。
After the water is drained from the overflow hole (the overflow pipe is not installed at this time) visual inspection of the barrel is clean, if there are foreign bodies, repeat the action until thoroughly clean.
4. 更后安装水箱堵头和溢流管,排气孔更好安装专用“伞”状排气装置(可防异物堵塞排气孔),忌安装长长竖起的简陋排气管,否则管路老化后易折引起排气不畅,从而使水箱抽瘪。
4. Finally install the water tank plug and overflow pipe, the best exhaust hole to install a special "umbrella" exhaust device (to prevent foreign bodies from blocking the exhaust hole), avoid installing a long erected simple exhaust pipe, otherwise the aging pipeline is easy to cause exhaust blocked, so that the water tank flattened.
5. 北方水质偏硬地区或农村打自备井安装太阳能的用户,售后人员应定期检查并清洗水箱水垢或泥沙。
5. Users who drill their own wells and install solar energy in areas where the water quality is relatively hard in the north or in rural areas should regularly inspect and clean the water tank scale or sediment after sales.